3412C Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Get a Quote
Minimum Rating 635 ekW
Maximum Rating 800 ekW
Emissions/Fuel Strategy Low Fuel Consumption
Voltage 220 to 480 Volts
Frequency 60 Hz
Speed 1800 rpm
Duty Cycle Standby, Prime
Engine Model 3412C TA, V-12, 4-Stroke Water-Cooled Diesel
Bore 5.4 in
Stroke 6 in
Displacement 1648.86 in³
Compression Ratio 13:00:01
Aspiration TA
Fuel System Pump and Lines
Governor Type ADEM™ A5
Length - Maximum 162.4 in
Width - Maximum 78.3 in
Height - Maximum 75 in
Dry Weight - Genset (minimum) 5761 lb
Dry Weight - Genset (maximum) 13275 lb
Air Inlet System
  • Air cleaner, single element canister type
  • Single element canister type
Control Panel
  • High coolant temperature
  • Customer data link (Modbus RTU)
  • Low coolant temperature
  • Low coolant level
  • Communications:
  • Run / Auto / stop Control
  • Engine Cycle Crank
  • Generator temperature monitoring module
  • Power Factor (per phase & average)
  • Remote CAN annunciator
  • Serial annunciator module data link
  • DC volts
  • Frequency (Hz)
  • Operating hours.
  • Emergency stop pushbutton
  • Digital I/O module
  • Local annunciator
  • Low Oil pressure
  • Oil pressure (psi, kPa or bar).
  • Emergency stop
  • Warning shutdowns:
  • Volts (L-L & L-N)
  • Remote Serial annunciator
  • Speed Adjust
  • Amps (per phase & average)
  • Voltage Adjust
  • EMCP 4.2B
  • Overspeed
  • coolant temperature
  • Digital Indicator for:
  • RPM
  • Accessory module data link
  • Failure to start (overcrank)
  • Controls:
  • Compatible with the following optional modules:
Cooling System
  • Caterpillar extended life coolant
  • Radiator with guard (sized for 50 degrees C)
  • Fan and belt guards
  • Coolant drain line with valve
Exhaust System
  • Stainless steel exhaust flex with ANSI style outlet flange
Fuel System
  • Primary and secondary fuel filters
  • Fuel priming pump
  • Water separator
Generator and Attachments
  • 3 Phase sensing
  • SR4B self excited
  • Class F temperature rise
  • VR6B Voltage Regulator
  • Busbar termination
  • 12 Leads
  • Class H insulation
  • 2:1 Volts / Hz
  • Reactive droop
Governing System
  • Cat electronic governor
Lube System
  • Oil drain line with valve
  • Lubricating oil
  • Oil filter
Mounting System
  • Base, formed steel with linear vibration isolators between base and engine-generator
Starting / Charging System
  • Battery with rack, cables
  • 45 Amp charging alternator
  • Fuel shutoff solenoid
  • 24 Volt starting motor
General
  • Paint - Caterpillar Yellow except rails and radiators gloss black
Air Inlet System
  • Air cleaner - dual element
  • Air cleaner - heavy element
  • Air cleaner - single element
Certificates
  • EU Certification
Circuit Breakers
  • 4 Pole circuit breakerswith shunt trip
  • 3 Pole Circuit Breakers with shunt trip
  • Power terminal strips
Control Panel
  • EMCP 4.3, EMCP 4.4
  • Temperature monitoring package
  • Vandal proof panel door
  • Generator running VFC
  • Earth leakage ground fault relay
  • Common alarm / shutdown relay
Cooling System
  • Jacket water heater
  • Radiator duct flange
  • Radiator removal
Exhaust System
  • Muffler 10 dBA attenuation
  • Manifold and turbocharger guard
  • Muffler 35 dBA attenuation
  • Elbow mounting kit
  • Through wall installation kit
Fuel System
  • Manual Fuel transfer pump
  • Automatic fuel transfer system
Generator and Attachments
  • Internal excitation (IE)
  • Anti-condensation heater
  • Permanent magnet excitation (PMG)
  • Oversize and premium generators
Governing System
  • Electronic load share
Lube System
  • Manual sump pump
Mounting System
  • Fuel tank base (1200 Ltr)
Special Tests / Reports
  • PGS test report @ 1.0 power factor
  • PGS test report @ 0.8 power factor
  • Factory witness test
Starting / Charging system
  • Oversize battery
  • Battery chargers
  • Heavy duty starting system
  • Battery disconnect switch
  • Battery removal
Enclosures
  • DC Lighting package
  • Weather protective enclosure (WP)
  • Sound attenuated enclosure (SA)