C4.4 Generator Set - Altorfer    

C4.4 Generator Set

C4.4 Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Engine Specifications

Bore
4.13in
Displacement
268.5in
Stroke
5in
Fuel System
Electronic (adjustable)
Engine Model
C4.4, In-line 4, 4-cycle diesel
Compression Ratio
18.2:1
Governor Type
Adem™A4
Fuel System
Electronic (adjustable)
Bore
4.13in
Displacement
268.5in
Stroke
5in
Aspiration
Turbocharged

Generator Set Specifications

Minimum Rating
36 ekW
Maximum Rating
100 ekW
Voltage
220 to 480 Volts
Frequency
60 Hz
Speed
1800 rpm
Emissions/Fuel Strategy
Non Regulated, EU Stage II
Duty Cycle
Standby, Prime

Generator Set Dimensions

Length - Maximum
75.8in
Height - Maximum
53.6in
Width - Maximum
44.1in

Standard Equipment

  • Air Inlet System
    • Air cleaner; light duty with disposable element
  • Cooling System
    • Radiator and cooling fan with guards
    • Coolant drain line with valve
    • Fan drive, battery charging alternator drive
    • Caterpillar extended life coolant
    • Coolant heater
    • Low coolant temp alarm
    • Low coolant level shutdown
  • Control Panel
    • EMCP 4.1
  • Exhaust System
    • Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
  • Generator
    • 12 leads
    • IP23 protection
    • Voltage regulator (single phase sensing)
    • Tower panel, IP22, bottom cable entry
    • Segregated low voltage (AC/DC) wiring panel
    • Circuit breaker, IEC, 3 pole, mounted in tower panel
  • Governing System
    • Mechanical and electrical governing system - model dependent
  • Lube System
    • Lubricating oil
    • Oil drain line with valve
  • Mounting System
    • Captive linear vibration isolators between base and engine-generator
    • Includes lifting provision and drag points
    • Termination points for coolant and lube oil drain lines
  • Starting/charging System
    • 24V battery with rack and cables
  • General
    • Engine and alternator pre-paint, Caterpillar yellow

Optional Equipment

  • Alternator System
    • R frame auxilliary winding
    • LC frame alternator
    • LC frame alternator with coastal insulation protection
    • Permanent magnet
    • 3 phase sensing
    • Quadrature droop kit
    • Anti-condensation heater
  • Circuit Breakers
    • Circuit Breaker Upgrades - 4 Pole circuit reaker to 250A, 400A and 630 A
  • Control Panel Options
    • EMCP 4.2
    • Volt free contacts
    • Speed adjust potentiometer
    • Voltage adjust potentiometer
    • Panel mounted audible alarm
    • Earth fault (2 wire only)
    • Earth leakage (2 wire only)
    • Overload shutdown via breaker
    • Battery charger
    • Emergency stop with key
    • Control panel heater
  • Enclosures
    • Sound attenuated Level 2 enclosure
    • Sound attenuated Level 1 (galv)
    • Rental pack - CAE rental option only
  • European Certifications
    • Upgrade to STD set for CE
  • Fuel System
    • Standard open set fuel tank / base supplied base, formed steel with single wall integral 8-hour fuel tank
    • Open set narrow base
    • Compact skidbase for open set
    • Skidbase for CALG enclosure sets
    • Bunded fuel tank
    • Low fuel level shutdown
    • Low fuel level alarm
    • High fuel level alarm
  • Global Certifications
    • Certification for CIS
  • Mounting Options
    • Electronic governor
    • Battery removal
    • External single point lift - enclosure
    • Industrial silencer
    • Silencer installation kit
  • Special Packing/inspectons For Shipment
    • PGS test report @ 1.0 power factor
    • PGS test report @ 0.8 power factor
  • General - Accessories / Miscellaneous
    • Stone guards / rad trans flange
    • Packing case - compact set
    • Packing case - canopied set